Fiat Ducato (250) - Water ingress in turbocharger | HELLA

Fiat

Ducato (250)

Model year: from 2010 onwards

Engine: 2.3 JTD/3.0 JTD (Euro 5)

Water ingress in turbocharger

In the vehicles mentioned above, there is a risk of the turbocharger failing due to water ingress.

The ingress of water into the pressure canister or position sensor on the turbocharger may cause damage to the components. This impairs control of the turbocharger. Error codes are stored in the control unit. In some cases, the engine may cease to run except in "emergency running" mode.

This issue applies to vehicles with the following turbochargers:

Garrett 806850-xxx (2.3 JTD)

Garrett 796122-xxx (3.0 JTD)

In order to permanently remedy the issue, the following points should be observed when replacing components:

All Fiat service measures must be complied with. For example, there is a modification to the water drainage system above the engine. For more information, please contact your authorized dealer.

Mini F56 - water ingress in the vehicle interior

In the Mini F56, water may collect in the driver or front passenger footwell. You can find the solution here.

Reading time: 2 minutes

VW T6 - engine does not reach operating temperature

In the VW T6l it can happen that the engine temperature display stops at approx. 70 °C. No errors are stored in the engine control unit. Here’s the solution

Reading time: 2 minutes

BMW 1 Series - Air conditioning system noises

An undefinable buzzing noise heard in the BMW 1 Series when the air conditioning is switched off may be caused by the air conditioning compressor

Reading time: 1 minute

Nissan Navara (D40) - Constant coolant loss

A steady loss of coolant discovered in a Nissan Navara may be caused by cracks in the cylinder head. What can be done?

Reading time: 1 minute

Mercedes W168 W210 Air conditioning system failure

Reading time: 1 minute

Volvo XC90 S90 V90 Condensation in vehicle interior

Reading time: 1 minute

MINI R50 R53 Failure of the Radiator Fan

Reading time: 1 minute

Fiat Freemont Loss of refrigerant

Reading time: 1 minute

Citroen C3 Coolant temperature warning lamp lights up

Reading time: 1 minute

Hyundai Terracan Engine goes into limp home mode

Reading time: 1 minute

Not helpful at all

5

4

3

2

1

Very helpful