Volvo V60 D4 2.0 16V CDI - Vehicle has no power | HELLA
Volvo V60
D4 2.0 16V CDI
Engine code D4204 T5
Model year 2010-2013
Vehicle has no power
Error code P0299
"Boost pressure too low"
If the fault symptoms described above occur together with error code P0299, a possible cause may be a faulty charge air radiator hose.
Due to a mechanical defect of the charge air radiator tube holder, contact with the pulley and the charge air hose occurs, resulting in damage.
In this case, check hose and holder and replace where necessary.
Repair notes
The problem was acknowledged by the vehicle manufacturer and fixed in the context of a service campaign installing different components, charge air radiator hose and charge air tube. It is possible that not all vehicles have been checked.
This defect may also occur in other models with the same type of engine.
Further technical information
Repair Tips
Maintenance Hints and Tips - Overrunning alternator pulley
Reading time: 1 minute
Repair Tips
Suzuki Swift - ESP makes noises when car starts off
On the Suzuki Swift (A2L), noise may be generated by the ESP hydro unit when car starts off. What action should be taken and what could be the cause of this problem?
Reading time: 1 minute
Repair Tips
Nissan Navara - Power loss - Error code P0093
The Nissan Navara may experience a loss in engine power, rough idling and an additional stored error code P0093
Reading time: 1 minute
Repair Tips
Fiat 500 X - unable to remove ignition key
In the Fiat 500 X, faulty ESP/ABS control unit software may lead to various symptoms. What are the causes and what can you do?
Reading time: 1 minute
Repair Tips
Opel Adam - engine cuts out after cold start
In the Opel Adam, faulty software in the engine control unit may lead to various symptoms. What are the causes and what can you do?
Reading time: 1 minute
Repair Tips
Nissan X-Trail - Error code P1489
A software weakness in the engine control unit of the Nissan X-Trail causes the engine check lamp to light up and the error code P1489 is displayed.
Reading time: 1 minute
Repair Tips
Toyota Aygo - Airbag control lamp lights up
With the Toyota Aygo it can happen that the airbag control lamp is permanently on and the error memory cannot be cleared.
Reading time: 1 minute
Repair Tips
VW Transporter T6 - Rough idling/engine stalls
Does the VW T6's engine stall or run roughly when cold? There may be error codes stored in the control unit. Remedy?
Reading time: 1 minute
Repair Tips
Hyundai Tucson - P0320 and the engine won’t start
In the Hyundai Tucson, it can happen that the engine starts sluggishly or not at all. There may also be ignition misfiring. The remedy for all this can be found here!
Reading time: 1 minute
Repair Tips
Fiat 500 / 500C - engine control lamp lights up
On the Fiat 500, a software flaw in the engine control unit can cause the engine control lamp to come on while the car is being driven
Reading time: 1 minute